COLLISION REPAIR INFORMATION FOR THE TOYOTA DEALER
Short Description
In today’s body shop environment high strength steel (H.S.S.) body parts are frequently welded during collision damage repairs. Typical uses for H.S.S. are the front cross member, front body outer pillar, floor side member and door side impact protection beam. Because H.S.S. is used in these areas of potential high stress, repairs must be done properly to maintain the structural integrity of the vehicle.
Website: www.toyotapartsandservice.com | Filesize: 46kb
No of Page(s): 5
Read more
Lexus Technical Bulleting - CHILD RESTRAINT SEAT TOP STRAP BRACKET INSTALLATION
Short Description
Child restraint seat top strap bracket installation procedures are provided to supplement the Owner’s Manual. Beginning with 2001 models, the top strap brackets are factory installed.
Website: www.ih8mud.com | Filesize: 174kb
No of Page(s): 4
Read more
HONDA 360/400/600 SEDAN & VAN SHOP MANUAL (2nd Edition)
Short Description
This manual is prepared to provide the service personnel of Honda dealers with complete informatoin on the maintenance and repair of Honda Car Models N360, N400, N600 and Station Wagon Model LN360 and their variants.
The information and instructions are grouped according to the type of work to be performed, such as diagnosis and testing, frequently performed adjustments and repairs, overhaul, etc. Specifications, special tools and maintenance instructions are found at each major section.
Website: www.honda600coupe.com | Filesize: 2458kb
No of Page(s): 35
Read more
Technical Bulletin FRONT SEAT SQUEAK NOISE 04 07 Toyota & Scion
Short Description
Some customers may experience a squeak noise due to contact between the seat track locating pin(s) and the floor pan location hole(s). The following procedure describes the repair method to correct this condition.
Website: www.scionbeat.com | Filesize: 50kb
No of Page(s): 5
Read more
REPAIR MANUAL SUPPLEMENT VEHICLE PULLING TO ONE SIDE
Short Description
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints. This information supplements Repair Manual procedures when the symptoms are:
- The driver holds the steering wheel without exerting steering effort while driving straight ahead, the vehicle drifts to the right or the left.
- While driving straight ahead, the driver has to steer either to the right or the left to maintain straight driving.
Website: priuschat.com | Filesize: 89kb
No of Page(s): 11
Read more
Toyota Prius Chassis Rail Repairs
Short Description
In 2004 Industry Research focused its Low Speed Crash Test Program on Hybrid vehicles, the two crashed were the Toyota Prius and Honda Civic Hybrid. Information has come to light with regards to repairs to the Prius. As a result of the test, the right hand front chassis was damaged. Normally the creasing would not be enough to require replacement. A substantial repair allowance was thought to be the correct method of repair.
Website: www.industryresearch.com.au | Filesize: 127kb
No of Page(s): 2
Read more
TOYOTA URETHANE ADHESIVE SEALANT FOR FIXED GLASS INSTALLATION
Short Description
In order to comply with FMVSS 212 – Windshield Retention and FMVSS 216 – Roof Crush Resistance, the factory uses a urethane adhesive sealant with bonded strength of not less than 40 kilograms per square centimeter or 569 pounds per square inch for certain bonded windshields and rear windows on Toyota vehicles. A Urethane adhesive sealant of at least equivalent strength must be used to maintain these retention and roof crush standards when windshield glass replacements are performed by either the dealer or an outside glass shop.
Website: dutch.northwestmr2.com | Filesize: 14kb
No of Page(s): 3
Read more
